Tests have been carried out to prepare straw for further gasification. Task statement: it is necessary to obtain a homogeneous suspension from straw for further gasification in the Customer’s methane tank in Serbia. To solve the problem, GUUMP was used for wet grinding, as well as DEVA-C to increase the yield of the gaseous fraction […]
Preparation of straw for gasification Read More »
Task: to mix petroleum products, primarily diesel and kerosene, to obtain a homogeneous emulsion. Solution: The DEVA-OIL complex was used.6 based on a flow-through cavitator. The complex is installed on the street, between the diesel storage tanks. The effectiveness of the complex is noticeable even visually: the mixture after treatment in DEVA-C becomes cloudy much
DEVA-OIL.6 for mixing petroleum products, Novosibirsk Read More »
In October-November 2023, commissioning and start-up works were completed for the launch of the DEVA-F.PRO complex at the enterprise LLC “Bonus” in Vyborg, Leningrad Oblast. The enterprise specializes in the production of organic and organomineral fertilizers from peat. It’s notable that the technological equipment occupies approximately 36 square meters, where the following are located: Only
DEVA-F.PRO for the production of organic fertilizers from peat. Vyborg. Read More »
The DEVA-S multifunctional system performs cavitation processing of liquids and suspensions in a static reactor.
DEVA-S Multifunctional Cavitation System Read More »
Task: production of organic fertilizers (OF) from bird droppings. Problems: there is a large amount of bird feather in the litter, which is not crushed by conventional dissolvers the initial raw material (litter, manure) is a heterogeneous, hard-to-process mass. Solution: WMM is used to obtain a homogeneous suspension (slurry) from bird dropings. Litter,
WMM for producing organic fertilizers from bird droppings. Tul’skaya region Read More »
Static Reactor Task: reducing the viscosity of the heated tar in the thermal cracking unit.
Static reactor for reducing tar’s viscosity. Oil-refinery, Samarskaya region. Read More »
Problem: produciong of the coal-water slurry (CWS) from brown coal (leonardite). CWS is used then for producing organic fertilizers (OF). OF are sold both for the wholebuyers and on retail market. Solution: WMM is used for producing homogeneous the coal-water slurry. Average grainseze is below 70 mkm (D90). New generation control shelf is
WMM for organic fertilizers production from leonardite (brown coal). Krasnoyarsk city Read More »
Task: Production of a water-diesel emulsion, improving the properties of fuel for a diesel-generator. Solution: use of the DEWA-OIL complex based on a static reactor. The resulting emulsion is stable for at least 20 minutes, which is long enough to be fed into a diesel generator running at peak power to generate electricity at high
DEWA-OIL for producing diesel-water emulsion. Germany Read More »
